cylindrical air filter

Q: What is the difference between high quality air filter and the low quality air filter

A: Just like we ate some not clean food, The shoddy air filter will not create the damage to the engine all of a sudden. Overtime, it is caused irreversible damage gradually. Stat not good, not enough force and black smoke these phenomenon often happed in the process of using. Also accompanied by the power decline and fuel consumption increased, after a long time, even if the replacement of air filter can not solve the problem.

Because low quality air filter made from inferior filter paper. The production technology also not good, this lead to the flow resistance increased, filter efficiency reduced. Finally affects the performance of engine and equipment.

Good quality air filter with low flow resistance, high filter efficiency, great dust hold capacity so engine can get minimum fuel consumption and maximum power, can extend the service life of the engine.

 Q: Buy a few cheap and poor quality air filter and increase the replacement times does this can ensure the normal operation of engine?

A:  Some people used the poor quality air filter to replac the good one, they think use the same money to buy more ordinary filters then keep the frequent air filter replacement can protect the engine. In fact it is not worth the cost.

Because the filter efficiency of poor quality air filter is very bad, some even can not filter, their service life is unpredictable, we don’t know when should replac it, Meanwhile a lot of impurities which can cause the wear on engine is flowing into your engine, you can not get the engine support but will spend much money for repairs

 Q: If the air filter was damaged or fail to replacement timely what effect will cause to the engine

A:  (1) cylinder wear (2)  the early wear of piston ring (3) equipment power shortage  (4) maintenance costs increased (5) will greatly shorten the life of the engine, and even scrapped

Q: Does frequent maintenance of air filter can extend the service life of engine?

 A: On the contrary, excessive maintenance will not only increase the maintenance cost, but also creates a risk of engine damage caused by following reasons: 1. Improper operation may make filter damage 2. Incorrect installation steps 3. The initial filter efficiency is low after each replacement.